Exterior Paint Body Color. How to Order .... school bus second â¢â¢â¢â¢â¢â¢â¢â¢â¢â¢â¢. ...... Fordomatic. Aut
1948 -1956 FORD TRUCK PARTS AND ACCESSORIES
TEXT
CATALOG
1948-1956 CHASSIS
MOTOR COMPANY
COPYRIGHT © 1964 - FORD MOTOR COMPANY. DEARBORN, MICHIGAN FORM FD 9464
GENERAL INFORMATION
SECTIONS 10-29 WHEELS, BRAKES
-
PAGE
II 1
SECTIONS 30-36 FRONT AXLE, STEERING
115
SECTIONS 40-48 REAR AXLE, DRIVE SHAFT, COUPLING SHAFT
139
SECTIONS 50-55 FRAME, MUFFLER, SPRINGS
231
SECTIONS 60-67 ENGINE
259
SECTIONS 70-75 STANDARD TRANSMISSION, CLUTCH
323
SECTIONS A70-A71 AUTOMATIC TRANSMISSION
447
SECTIONS 80-86 COOLING, GRILLE
471
SECTIONS 90-97 FUEL, CARBURETOR, ACCELERATOR
493
SECTIONS 100-123 GENERATOR, ALTERNATOR STARTER, DISTRIBUTOR
651
SECTIONS 130-145 LAMPS, WIRING
707
SECTIONS 160-166 FENDER, HOOD
727
SECTIONS 170-182 BUMPER, SHOCK ABSORBER, HEATER, ACCESSORIES
739
BODY SECTIONS - ALL
769
SOFT TRIM SECTION
789
1953-1956 BODY
PARTS AND ACCESSORIES OPERATIONS FORD DIVISION
QUICK REFERENCE INDEX
1964
Copyright © 2012, Forel Publishing Company, LLC, Woodbridge, Virginia All Rights Reserved. No part of this book may be used or reproduced in any manner whatsoever without written permission of Forel Publishing Company, LLC. For information write to Forel Publishing Company, LLC, 3999 Peregrine Ridge Ct., Woodbridge, VA 22192
1948-56 Ford Truck Master Parts and Accessories Catalog EAN: 978-1-60371-087-9 ISBN: 1-60371-087-6 Forel Publishing Company, LLC 3999 Peregrine Ridge Ct. Woodbridge, VA 22192 Email address:
[email protected] Website: http://www.ForelPublishing.com
This publication contains material that is reproduced and distributed under a license from Ford Motor Company. No further reproduction or distribution of the Ford Motor Company material is allowed without the express written permission of Ford Motor Company.
Note from the Publisher This product was created from the original Ford Motor Company’s publication. Every effort has been made to use the original scanned images, however, due to the condition of the material; some pages have been modified to remove imperfections.
Disclaimer Although every effort was made to ensure the accuracy of this book, no representations or warranties of any kind are made concerning the accuracy, completeness or suitability of the information, either expressed or implied. As a result, the information contained within this book should be used as general information only. The author and Forel Publishing Company, LLC shall have neither liability nor responsibility to any person or entity with respect to any loss or damage caused, or alleged to be caused, directly or indirectly by the information contained in this book. Further, the publisher and author are not engaged in rendering legal or other professional services. If legal, mechanical, electrical, or other expert assistance is required, the services of a competent professional should be sought.
II
FORD TRUC/( "ARTS
GENERAL INFORMATION
PARTS and ACCESSORIES TEXT CATALOG FORM FD-9464
FORD DIVISION~MOTOR COMPANY
1948/56
FORD TRUCKS
DISTRICT OFfiCES
Atlanta (East Point, Ga.) Boston (Natick, Mass.) Buffalo, N. Y. Charlotte, N. C. Chicago (Melrose Park, Ill.) Cincinnati, Ohio Cleveland, Ohio Dallas, Texas Davenport, Iowa
Denver, Colo. Louisville, Ky. Memphis, Tenn. Des Moines, Iowa Detroit New Orleans (Livonia, Mich.) (Arabi, La.) Fargo, N. D. Newark Houston, Texas (Teterboro, N.J.) Indianapolis, Ind. New York Jacksonville, Fla. (White Plains, N. Y. ) Kansas City, Mo. Oklahoma City, Okla. Lansing, Mich. Omaha, Neb. Los Angeles Phoenix, Arizona (Pico-Rivera, Calif.)
Philadelphia (Pennsauken, N. J.) Plttsburgh, POI.. Richmond, Va. Rockford, Ill. St. Loui$ (Clayton, Mo.) Salt Lake City, Utah San Jose, Calif. Seattle, Wash. Twin City (Minneapolis, Minn.) Washington, D. C.
INDEX FOR GENERAL INFORMATION SECTION
Abbreviations Appearance & Maintenance Materials BASIC BODY PARTS NUMBERING SYSTEM
Body Type Codes Catalog Model Codes District Offices Explanation of Symbol Ford Group and Basic Number Chart General Instructions How to Order Parts Model Identification Model Years Nomenclature Index Paints Procedure for Using Catalog Quick Reference Index Section, Group and Basic Numbers Standard and Utility Hardware
*
VI XV thru XX III III
Rating Plate Diagram & Explanation Rating Plate Codes:
m
Assembly Plant D. S. O. Codes District Engine (Horsepower Rating) Exterior Paint Body Color Model Year Production Date Transmission Type Truck Series and Catalog Model Symbols
II IV
VII thru IX II IV XXI thru XXVI IV IV XIV V I V IV
GENERAL INSTRUCTIONS
This Ford Parts and Accessories Catalog contains parts information for Ford trucks and is to be used in conjunction with "Illustration" Catalog, Form FD-9465. Following are the model years for which parts information is provided in this catalog: Chassis Parts. . Body Parts . . . . Soft Trim Parts .
X
1948 through 1956 1953 through 1956 1956
The driver's side is the left hand side of the vehicle and should govern in determining such parts as fenders, lamps, etc. as to whether a part is right or left hand.
XI X XI XI XIII XI X XI XII
'tlRD TRUC/( flARTS
GENERAL INFORMATION
SECTION, GROUP and BASIC NUMBERS
For greater convenience this catalog is divided into sections to conform with the Master Parts Catalogs. Section Numbers are related to group numbers as follows: SECTION NUMBER
10 20
GROUP NUMBER SERIES
PART NAME
1000 - 1999 2000 - 2999
Wheel Parts Brake Parts
The "Illustration" Catalog is divided into sections also and like parts are shown under similar section numbers in both the "Text" and "Illustrations" catalogs. Illustrations contain basic group numbers only; therefore, it is necessary to refer to the basic group within the "Text" Catalog listing for complete applicable part number. Most basic group numbers consists of numerals only, however, some basic numbers include an alphabetical character also. In this catalog basic numbers expanded by an alphabetical character follow the numerical basic numbers from which they are expanded and are listed in the manner shown below: 2140 Cylinder assy. - Brake Master Tube - Brake Booster to Tee 2A140 PROCEDURE FOR USING CATALOG
Refer to Pages VII thru IX for more information on Ford group and basic part numbers. Following is a recommended procedure for using this catalog: Should an inquiry be received for a front hub assembly for a 1956 C-600 cab forward model, use the following steps. A.
Refer to the General Information Section for an explanation of the Catalog Model Symbols. On page XII under 1956 the catalog model symbol for truck series C-600 is shown as "WH".
B.
Refer to the section and page designated in the Quick Reference Index on the cover for 'Wheels".
C.
On the designated page (1) will be an index.
D.
Refer to the alphabetical nomenclature under heading 'Wheels, Hubs and Drums", find name Hub Assy. (Front). The group number will be shown as 1104.
E.
Refer to Group 1104 and locate the year 1956 in the column headed 'Year". Refer then to column headed 'Model" for 'WH" which indicates a C-600 cab forward. The part number will be shown as B4T 1104-B.
In the event the proper nomenclature is in doubt, an alternate method of locating the basic or group number would be as follows. A.
Refer to the section and page designated in the Quick Reference Index of the Illustration Catalog, Form FD 9465, for 'Wheels".
B.
On the designated page (1) is an index of various Wheels, Hubs and Drums.
C.
Refer to page XIII of the General Information Section for the Catalog Model Symbols for the various truck series.
D.
On page (1) locate the applicable illustration for 1956 Front Wheels and Related Parts for Model 'WH".
E.
Refer to illustration on page 6 and identify the proper part which will show the basic group number as 1104.
F.
Refer to Group 1104 in the 'Text" Catalog, Form FD 9464, and locate the year 1956 in the column headed 'Year". Refer then to the column headed 'Model" for 'WH" which indicates a C-600 cab forward. The part number will be shown as B4T 1104-B.
v
VI
GENERAL INFORMATION
FORD TRUC#( "ARTS ABBREVIATIONS
& ••••••••••••••••••••••••••••••• , and accel. ••••.•••••••••••••••• accelerator
adapt. • • • . • • . • • • • • • • • • • • • • • • •• adapter adj •••••••••.•••••• adjusting-adjustment alum. • • • • . • • • • • . • • • • • • • • • . •. aluminum amp •••••••••••••••••.••••••.•• ampere approx ••.•••.••••••••••• approximately AR •••••••••••••••••.•••••• as required ass'y ••••••••••••••••••.••••• assembly aux ••••.••••••••••••••••••••• auxiliary 2/B•••••••.•.•••••••••••.•••• 2 barrel 4/B••••••••.•••••••••••.••••• 4 barrel BBC ............. bumper to back of cab brg ••••••••••••••••••••••••••• bearing brkt ••••••••••••••••••••••••••• bracket C2, C4. ..........•. Carter 2 or 4 barrel cap •••.••••••••••••••••••••••• capacity carbo •••••••••••••••••••••• carburetor elF.............•........ . cab forward c/member .••••••••••••••• crossmember conn. • • • • • • • • • • • • • • • • • • • • •• connection Conv..................... Conventional cov., cvr ..••.•..••.•.••••...••.• cover CPo •••••••••••••••••••.• candle power c/pin •••••••••..•••••••••••• cotter pin c/shaft••••••••••••••••••••• crankshaft ctr •••••••••.•••••••.••••••••.•• center cyl. ••••••••••••••••.•.••••••• cylinder D/D•••••••••••••••••••••• direct drive defl. • • • • • • • • • • • • • • • • • • • • • • •• deflector dia. , diam ••••••••••••••.••••• diameter diaph •••.•••••••••••••••..•• diaphragm disp ••••••••••••••••••••• displacement dist .••.•••••••••••••••••••• distributor ea ••••••••••••••••••••••••••••••• each E/H/D •••••••••••••••• extra heavy duty em/re•••••••••••••• emission reduction eng •••••••••••••••••••••••••••• engine ext•••••••••••••••••••••••••• extension F2, F4. __ ... ___ .. _.. Ford 2 or 4 barrel F / A, F /axle ...... _•...... forward axle fdr •••••••••••••••••••••••••••.•fender fill ••••••••••••••••••••••••••• fillister F /M ••••••••••••••••••••••• Fordomatic frt •••••••••• _•••••••.••••••••••.•front
ft •.••••••••••.••••••••••••••••••• foot f/wheel. •••••••••••••••••••••• flywheel F /ward ...................... Forward gal •••••••••••••••••••••.••••••• gallon gen ••••••••••••••••••••••••• generator
rad. • • • • • • • • • • • • • • • • • • • • • • • •• radiator recirc. • • • • • • • • • • • • • • • • •• recirculating reinf ••.••••••••••••••••• reinforcement rep!...... • • • • . • • • . • • • • • • • . •• replaced
req'd ••••••••••••••••••••••••• required gov .•••••••.••••••••••••••••• governor ret ••••••••••••••••••••••••••• retainer G. V. W•••••••••••• gross vehicle weight R. H•.•••••••••••••••••••••• right hand HI, H2, H4 ........ Holley 1,2 or 4 barrel R. P. M•••.•••••• revolutions per minute hd •••••••••.••••••••••••••••••••• head H/D •••••••••••••••••••••••• heavy duty rr ••••••••••••••••••••••••••••••• rear R/R •.••••••••••••••.•••••• roadranger hel •••••••••••••.•.•••••••••••• helical hex ••••••••••••••••••••••••••• hexagon r/wheels •••••••••••••••••• rear wheels H/D R/R. • • . . • •• heavy duty roadranger SIB•.•.•••••••••••••.•••••. school bus hsg ••••••••••••••••••••••••••• housing H/V•••••••••••••••••• hydraulic vacuum second •••••••••••.•••••.•••• secondary hyd. • • • • • • • • • • . • • • • • • • • • • • •• hydraulic s/member ••••••••••••••••• sidemember I. D••••••••.••••••••••• inside diameter spec ••••••••.•••••••••••••••••• special instr., instru •••••••••••••••• instrument SjE, Spec. Econ........ Special Economy speedo ••••••••••••••••••• speedometer inter •••••••••••••••••••••• intermediate "L" •••••••••••••••••••••••••••••• left spg ••.•••••••••••••••••••••• , •• sprmg sq ••••.•••••..•.••.•••••••••••• square lb •••••••••••••••••••••••••••.•• pound L/D ••.••••••••••••••••.••••• light duty siring ••••••.•••••••••••••••• snap ring std. • • • • • • . • • . • • • • . • • • • • • • • •• standard L. H•••••.••••••••••••••.•••••left hand LHD ••••••.••••••.•••••• left hand drive S/T •••••.•••••••• standard transmission suppt. • • • • • • . • • • • • • • • . • • • • • • •• support lub .•••••••••••••••••••••••• lubricator l/w, l/washer ••••••••••••••• lockwasher syn .••.•.•••.••••.••.••.••••• synthetic T/A•••••••.•••.••••••••••• tandem axle lwr ••••••••••••••••••••••••••••• lower T/C, T/Cab ................... Tilt Cab man ••••.••••••••••••••••••••• manifold MA/D. .....•........-.... Maximum duty T/M •••••.••••••••••••••••• Transmatic trans ••••••••••••••••••••• transmission M/D ••••••••••••••••.••••• medium duty T /T ................... Tractor Trailer m. m •.•••••••.••••••••••••• millimeb3t U. D., U/D •••••••••.••••••• under drive mtg .••••••••••••••••••••••••• mounting u/joint, u/jt••••••••••••• universal joint mtr •.••••••••••••••••••••••••••• motor l,J/S .••••••••••••••••••••••• undersize No •••••••••••••••••••••••••••• number vac •••••••.•••••••••••••••••••• vacuum O. D•••••••••••••••••• outside diameter vent .••••••••••••••••••••••• ventilation O/D........................ overdrive vlv ..•••••••.••• " .••.•••••••••••valve O/S •••••••••••••••••••••••• oversize w/ ••••••••••••••••••••••••.•••••• with park •••••••••••...•. _••••••••• parking wash •••••••••.•••••••••••••••• washer pass •••••••••••••••••••••••• passenger w/b, W/B. • • . . • . . . . • . • . . . . .. wheelbase pcs •••••••.•.•••••••••••••••••• pieces W/G .......... _. _... _. _.. with governor P/D .................. Parcel Delivery w/out, w/o ••••••••••••.••••••• without pis •••••••••••••••••••• power steering w/s, w/shield ............... windshield P. T. 0 ••••••••••••••••• Power Take Off X •••• _• _.••••••••••.•••••••• exclusive qt .••••••.•••••••••••••••••••••• quart X/C _............... _.... extra cooling X/H/D. • • • . • • . • • •• exclusive heavy duty X/H/D R/R....... exclusive heavy duty roadranger
FORD TRUC/( PARTS
GENERAL INFORMATION
VII
FORD MOTOR COMPANY BASIC PART NUMBERING CHASSIS, ENGINE AND ELECTRICAL BASIC NUMBER SERIES
1AOOO·1A250 1A251·1A349 1A350·1A499 1A5OO·1A724 1A725·1A999 2AOOO·2A594 2A595·2A874 2A875·2A999 3AOOO-3A499 3A5OO·3A776
Wl1te1$, Hub$,.rid DrumS Open II1Jmlle" . Sfr: \Vlletl 0IJrIfr T reund Tulles Open II1Jmbel$ Brakes Br.ke$"-1'trkilla Air Comprt$$Or .' . . '.. FI'OIIt Axles and Front Su$ptMionS'.·.
SleeriIIl .Gear IAdSteerlJi, Y(!IW.
'.
13800·1394& l",13999
13A800·13A949 13A950·13A999
14000·1_
14AooO·14A689
1_~14 .. ')' 1472S-1=
14A69O·14A724 14A725·14A999
...
3A777 ·3A999 4AOOO·4A999 5AOOO·5A149 5AI50·5AI99 5A200·5A299 5A3oo·5A350 5A351·5A416 5A417·5A454 5A455·5A481 5A482·5A499
-7000-7499 7IiOO-764t
." . ~JI, ...
. =:=
'.
5A5OO·5A515 5A516·5A999 6AOoo·6A899 6A900·6A944 6A945·6A999 7AOOO· 7A499 7A5OO·7A649 7A650·7A799 7A8oo·7A999 8AooO·8A499
8A500·8A599 8A6oo·8A669 SA670·SA999 9AOOO·9A269 9A270·9A339 9A340·9A423 9A424·9A499
9500-9599 9600-9699 9700·9899
9A500·9A599 9A600·9A699 9A 700-9AS99
9900·9999 10000·10299 10300·10399 10400-1Q499 10500·10649 10650-10831
9A9oo·9A999 10AOOO·10A299 10A300·10A399 10A400·10A499 10A500·10A649 IOA650·10AS37
10838·10999 11000-11529 11530-11568 11569-11619
IOA838·IOA999 11AOoo·11A529 11A530·11A568 11A569·11A619
11620-11644 11645-11688 116&9-11999 12000-12399
llA620·11A644 11A645·11A688 11A689·11A999 12AOoo-12A399
1240&-12427 12428-124411
12A400·12A427 12A428·12A449
_In. .
Open Numbers'. ' .... " •. Rear Axlt Illd Dr~.1t Jft!i.
Shaft .....,. Frama and BraClults
Mumer, Exhaust 1'1"$, aAd Brackets Front Springs. . . Sub·Frama (For Cab Mountllll) Open "umbe~s' Front tillIS-Clips, Studs, _nd •.. Busb illS . . Stabilizer and AttacbllllPatl$
15000'1~; 15200-15299.' 153(lO-IS399· . 15400-15489.
151l5-151~".
15AooO·15A039 15A04O·15A074 15A075·15A114 15A115·15A199 15A2oo·15A299 15A300·15A399 15A400·15A489
15490.15S4§ 15550-15579 15580-15599. 151iOO-15649 . 15$50.-15655 . 15656-15899 15700-15724. 15725-15159
15A49O·15A549 15A550·15A579 15A580·15A599 15A6oo·15A649 15A650·15A655 15A656·15A699 15A7oo·15A724 15A725·15A759
15760-15799 15800-15849,
15A760·15A799 15A8oo·15A849
15850·15874 15815·15899 15906·15999 16000·15249 16250-16299 16.100-16449 16450-1£549 16550-16579 16580-16599 16600-16999
15A850·15A874 15A875·15A899 15A9oo·15A999 16AOoo·16A249 16A250·16A299 16A300·16A449 16A450·16A549 16A550·16A579 16A580·16A599 16AGOO·16A999
Generators Alternator and Reetlfier Open Numbers Generator Regulator . Battery a nd Supports-Voltmeter and Charge Indicator Instrument Cluster and Controls Starting Motor and Starter Switcb Open Numbers Ignition Switch
17000·1714t 17150·17249 17250·11384 17385·17399 11425-17599 17600·11674 11675-17748 tn49-17999
17400-114f4
17AOOO·17Al49 17A150·17A249 17 A250-17A384 17 A385·17 A399 17A4oo·17A424 17 A425·17 A599 17 A600·17 A674 17A675·17A748 17A749·17A999
0t:n Numbers l ,hting Switch Op&n Numbers Ignition Coil, Oistributor. Con· denser and Diaphragm Spark Plugs Open Numbers
18000-18199 18200.1= 18242·1 18700-18799 18600·19499 19500·19549 19550-19999
18AOOO·1SA199 18A2oo·18A241 ISA242-18A699 ISA700·18A799 18ASOO·19A499 19A5oo·19A549 19A550·19A999
front SprJng Covers ..' Rear Springs and Attacblng Parts . Engine and Mounts· . .
.
Enr: Installation Ind Dms:oll
Transmlulonand Sbifting Control$ Cluteh and Controls . Transmlulon Overdrive Tor~ue Convertw .. Rad ltOr and GrUle Patl$
Water Pumps Fan and Brackets Open Numbers Fuel Tank Fuel and 011 Gauges and Fue! Tubes Fuel Pumps Manitold, Clamps. Tbarmostats, etc. Carburetors Carburetor Air Cleaners Thermostatic Choke, Aee. Spark" Throttle Control Rods
*This serie$ has become inactive and parts qualifying wiH b. Identified with pari nllmb.,.. from a more appropriate ,erie..
1~15074
11075·15114 ".
.Lamp Assy.-BatII.up .. Lamp Assy.-Utility , ~mp Assy.-Police .Fhlshw Map ump ,Top
.ment Ulltp.·.· ..
Motolttite; fIot used Passe.;tet· ear; Trlltk
& Industrial Ell 8$ {)pen Nijmbers .' ... , LaIllPAHy.-TransmissiOn Con· trOl Selector IndiCator
.
Parklcake Signal Open bers
Front Fender and Aprons Iender Sltields Rear Fenders Running Board.s and Br4Ckets splash Shields Op&n Numbers. . Hood, &r.ac.k8l$, and Col\trol$,
Tools Open Numbers . Speedometer and Tacbo!lleter Open N.umbel'll Rear Window wiper Windshield WipW$ Windshield Washers Rear Vifw Mirrors Fron! arid Rear Bumpws arid Slone Deflectors .
.
Shoc:ll Absorbers
HealWl Air Brakes Radio. . MooUaneous A!II:IIssories Air Condition.ws
GENERAL INFORMATION
VIII
FORD TRUC/( "ARTS
BODY BASIC NUMBERS AND CORRESPONDING FUNCTIONS
I
USIC PUT NO. SERIES
BASIC SERIES EXPANSION
PARTS WHICH QUAlifY BY FUNCTIONAL AREA
·7000000-1000099 00100-00399 01400-01499 01500-01599 01600-01799 01800-01999 02000-02499 02500-02699 02700-02899 02900-02999 03000-03999 04000-04249 04250-04399 04400-04599
70oooAOO· 70000A99 00IAOO-003A99 014AOO-014A99 015AOO·015A99 016AOO·017A99 0I8AOO-019A99 020AOO·024A99 025AOO-026A99 027 AOO-028A99 029AOO·029A99 030AOO-039A99 040AOO-042A49 042ASO-043A99 044AOO·045A99
I
BASIC PART NO. SERIES
USIC SERIES EXPANSION
PUTS WHICH QUAlifY BY FUNCTIONAL AREA
Body Assembly & Trim Sets front End A$S8mbly Ventilating Dticts & Valves Brake Pedal SlIJIIIOrt Oash Assembly Ventilating Ducts & Valvu Cowl Assembl" front Body Pilar AMY. Open Body Front Tie Bow Braoes, Etc. Windshield Assembly Visor Assemb', Front Belt Rai Inst Pane' Ass:y. Panel AMy.-lnstr. Panel Details
25000-25099 25100-25299 25300-25399 25400-25699 25700-25899 25900-25999 25000-26199 26200-26399 26400-26599 26600-26699 26700-26799 2680Q.26899 26900·26999 27000·27199
250AOO·250A99 251AOO·252A99 253AOO-253A99 254AOO·256A99 257 AOO·258A99 259AOO·259A99 260AOO·261A99 262AOO-263A99 264AOO·265A99 266AOO·266A99 267AOO·267 A99 268AOO-268A99 269AOO·269A99 270AOO·27IA99
Rear Door frame & Pillar AMY. Rear Door Header Rear Door Bottom Rear Door Garnish Moulding Rear Ooor GlaM Open Rear Door Relnf. Rear Ooor GlaM frame Rear Ooor lock Rear Door Handles Open Rear Door Hinge Open Rear Door Regulator
27200·27299 27300·27399 27400·27699 27700·27199 27800-28099 28100·28399 28400.28499 28500·28599 28600·28699 28700·28799 28800·28999 29000·29199
272AOO·272A99 273AOO·273A99 274AOO·276A99 277 AOO-277A99 278AOO·280A99 281AOO·283A99 284AOO·284A99 285AOO·285A99 286AOO·286A99 287AOO·287 A99 288AOO·289A99 290AOO·291A99
29200-29599 29600-29699
292AOO·295A99 296AOO·296A99
Rear Door Check Rear Door Re.aulator Vacuum Uft Rear Door Tnm Erter Assy. uarter Panel Assy. arter Lock Pillar pen Quarter Keader suarter Frame uarter BeH Rail Open Quarter Window Garnish Moulding & Mouldin, Quarter Rein • Braoes & Brkts. Quarter Window Assy.
29700·29799 29800-29999 7030000·7030199
297AOO-297 A99 298AOO·299A99 70300AOO·70301A99
30200·30299 30300·30499 30500·30699 30700·30799 30800-30999 31000-31499 31500·31599 31600·31899
302AOO·302A99 303AOO·304A99 305AOO·306A99 307 AOO-307 A99 308AOO-309A99 31OAOO·314A99 315AOO·315A99 316AOO·318A99
31900·31999 32000·32199 32200·32399
319AOO·319A99 320AOO·321A99 322AOO·323A99
32400·32499 32500-39999 7040000-7040099 40100·40199 40200-40299 40300-40399 40400·40499 40500·40599 40600·40699 40700·40799 40800·40699 40900-40999 41000·41099 41100·41199
324AOO·324A99 325AOO·399A99 70400AOO· 70400A99 401AOO·401A99 402AOO-402A99 403AOO·403A99 404AOO·404A99 405AOO·405A99 406AOO·406A99 407 AOO·407 A99 408AOO·408A99 409AOO·409A99 41OAOO·41OA99 4I1AOO·41IA99
41200·41299 41300·41399
412AOO-412A99 413AOO·413A99
41400-41599 41500·41699 41700-41899 41900·41999 42000-42199 42200-42299 42300-42499 42500-42599 42600·42699 42700·42899
414AOO·415A99 416AOO·416A99 417AOO·418A99 419AOO·419A99 420AOO·421A99 422AOO·422A99 423AOO-424A99 425AOO-425A99 426AOO·426A99 427 AOO·428A99
42900-42999
429AOO·429A99
04600-04199
046AOO·047A99
04800·04899 04900·05999 06000-06199 06200-09999 *7010000-7010099 10100·10599 10600-10999 11000'11099 11100·11399 11400-11499 11500·11799 11800·11999 12000·12099
048AOO·048A99 049AOO·059A99 060AOO-061A99 062AOO·099A99 70100AOO·70100A99 101AOO-105A99 106AOO·109A99 1I0AOO·1I0A99 lIIAOO·ll3A99 1I4AOO·1I4A99 Il5AOO·lI7A99 1I8AOO-1I9A99 120AOO-120A99
Cigar Lighter Assy. & Inslfument Cluster Ash Receptacle Assy. Open Glove Compl. AMY. Open Floor Assembly Floor Side Member Assy. Floor Cross Sill AMY. Under Body Assy. Floor Pan Assembly Floor Pan Silenoers & Pads Floor Board AssY. Open Floor Board Riser
12100·12299 12300·12599 12600-12699 12700·12999 13000-13199 13200·13299 13300·13499 13500·13599 13600-13799 14000·14099 14100·14199 14200·14299 14300·19999 >7020000-7020099
121AOO·I22A99 123AOO·125A99 126AOO·126A99 127AOO·129A99 13OAOO·l3lA99 132AOO·132A99 133AOO-I34A99 135AOO·135A99 136AOO-137A99 140AOO·140A99 141AOO-141A99 142AOO·142A99 143AOO·199A99 70200AOO· 70200A99
Floor Trans. Cover Dust Sealer Open Floor Skid Strip Open Floor Mat & Cerpet Floor Stuff Plate Open floor Tool Box Open Member Assy.-Body Side front Member Assy.-Body Side Rear Sill Assy.-Floor Pan Cross Front Open BodY Side Assembly
20100·20199 20200·20399 20400-20499 20500·20699 20700·20799 20900·21099 21100·21299 21300-21399 21400·21799 21800·22199 22200·22399 22400·22499 22500·22599 22600·22699
201AOO·201A99 202AOO·203A99 204AOO·204A99 205AOO·206A99 207 AOO·207A99 208AOO·21OA99 2IlAOO·212A99 213Aoo·213A99 214AOO·217A99 218AOO·22IA99 222AOO·223A99 224AOO·224A99 225AOO-225A99 226Aoo·226A99
Front Door Front Door Panel Front Ooor Pillar Front Ooor Keader Front Ooor Bottom front Door Garnish Mldg. & Mldgs. Fronl Ooor Reinl. Open Front Door Glass Front Door lock Front Door-Glass Frame front Ooor Kandles open front Door HandleS-Inside
22700·22799 22800·22699 22900·22999 23000·23099 23100-23399 23400·23499 23500·23599 23600·23699 23100·23999 24000·24199 24200·24299 24300·24599 24600·24699 24700·24999
227 AOO·227 A99 228AOO·228A99 229AOO·229A99 230AOO·230A99 231AOO·233A99 234AOO·234A99 235AOO·235A99 236AOO-236A99 237 AOO·239A99 240AOO·241A99 242AOO-242A99 243AOO·245A99 246AOO·246A99 247 AOO·249A99
Open Front Door Hinge Front Door Ventilating Window Front Door Dovetail Front Door Regulator Fronl Door Window Regulator Front Door Check Open Front Door Trim Front Ooor Arm Rest Hydraulic Window Operating Center Pillar Ass:y. Rear Door Ass:y. Rear Door Panels
Quarter Window Glass Quarter GII$$ Channel Quarter Glass Run Quarter Window Reg. rarter Vent. Window oarter Window Regulator uarter Glass Frame Quarter Arm Rul Ash Receplecle Open gnarter Trim A$SY. & Assist Loop pen Qlf. Arm Rest A$SY. & Rear Seat Center Arm Rest 8ua~r Panel Spare Wheel Compt
~ Slats-Trim sticks-Anti· Squeaks
guarter Foldlnc Compl-Package pen . Back Ooor A$S8mbly LUfflage Compt Ooor Assy. T8 I Gate Assy. Back Panel Assy. lift Gate Open Lu~age Compl. Ooor Panel Ta Gite Panel Assy. Back Door frame AMY. TaU Gate Frame A$SY. Back Door Pillar fillers Open
Deck Pillar Group
l~age. Compt
ader Open
& lift Gate Door
~~k~:~:Wing
Sack Door Glass & framing Baek WindoW GlaM Baek Window frame Assy. Back Window Garnish MoUldin~ Back Door finish Strlp-Moul inas Tail Gate Cross Finish Strip Luggage Compl. Hinge A$SY.lampAssy. Baek Door Hinge & Reint. Assy.
FORD TRUC/( PARTS
GENERAL INFORMATION
BODY BASIC NUMBERS AND CORRESPONDING FUNCTIONS
BASIC PART NO. SERIES
IASIC I SERIES EXPANSION
PARTS WHICH QUAlifY BY fUNCTIONAl AREA
Tail Gate Hinge A$SY. Back Door lock A$SY. Tail Gate lack Assy. Luggage Camp!. lock Assy. Back Door Handle Assembly luggage CampI. Locking Handle Back Door Weatherstrip luggage CampI., Bumper & Weatherstrip Tail Gate Bumper·& Dowel Back Window Regulator Assy. Back Door Check Assy. lU~age Comp!. lid SupportCamp Open Tail Gate Support
43000·43099 43loo-43149 43150-43199 43200·43399 43400-43499 43500·43699 43700·43799 43800-43899
430AOO·430A99 431AOO·431A49 431A50·431A99 432AOO·433A99 434AOO·434A99 435AOO·436A99 437 AOO·437 A99 438AOO·438A99
43900-43999 44000·44099 44100·44199 44200·44299
439AOO·439A99 440AOO·440A99 441AOO·441A99 442AOO·442A99
44300·44399 44400·44599
443AOO·443A99 444AOO·445A99
44600-44699 44100·44799 44800·44999 45000-45099 45100·45199 45200·45299 45300-45399 45400.45599 45600:45699 45700·45199 45800·45999 45900·45999 46000-46099
446AOO·446A99 447 AOO·447 A99 448AOO·449A99 450AOO·450A99 451AOO·451A99 452AOO·452A99 453AOO·453A99 454AOO·455A99 456AOO·456A99 457 AOO·457 A99 458AOO·458A99 459AOO·459A99 460AOO·460A99
46100·46199 46200·46299
461AOO·461A99 462AOO·462A99
46300·46399 46400·46499 46600-46999 47000-47299 47300·47999 48000·48099 48100-49999 7060000·7050099 50100·50199 50200·50299 50300·50599 50600-50799 51400·51599
463AOO·463A99 464AOO·464A99 465AOO·469A99 470AOO·472A99 473AOO·479A99 480AOO·480A99 481AOO·499A99 70500AOO· 70500A99 501AOO·501A99 502AOO·502A99 503AOO·505A99 506AOO·507 A99 508AOO·512A99 513AOO·513A99 514AOO·515A99
51600·51699 51700·51799 51800-51899 51900·51999 52100·52299 52300·52399 52400·52499 52500·52599 52600·52699 52700·52999 53000-53099 53100·53199 53200·53299 53300·53399 53400·53499
516AOO·516A99 517AOO·517A99 518AOO·518A99 519AOO·519A99 521AOO·522A99 523AOO·523A99 524AOO·524A99 525AOO·525A99 526AOO·526A99 527 AOO·529A99 530AOO·530A99 531AOO·531A99 53ZAOO·532A99 533Aoo·533A99 534AOO·534A99
Roof Rib & Slats Roof Drip & Finish Moulding Roof Partition Roof Trim Panel Headlining Roof Headlining Support Roof Binding Roof Cardboard Top Back Curtain Open Top Deck & Slide Quarter Top Stack-Toggle Top landau-folding Pillar Top Back Curtain Hydraulic Group Top Curtain Container
53500·53599 53600·53699 53700·53199 53800-53899 53900'54199 54200·54299 54300·54399 54400·54499 54500--54599 54600·54699 54700·54799 54800·54899
535Aoo·535A99 536AOO·536A99 537 AOO·537 A99 538AOO·538A99 539AOO·541A99 542AOO·542A99 543AOO·543A99 544AOO·544A99 545AOO·545A99 546AOO·546A99 547 AOO·547 A99 548AOO·548A99
Top Side Front Curtain Top Side Rear Curtain Top Covers, Pads and Retainers Quarter Curtain Folding To~ Top Back tay Roof Pads & Wadding-Silencers Top Oust Hood & Container Open Top folding Campi. Roof weatherstr~ Top Hold Down trap
gfTl08:~g~
Back Reinl. Brackets Back Door Reinf CampI. Opening Rein!. Tali Gate Reinforcement lu~a,e. Compl. Drain Trough Bac rtm Back Curtain Luggage Comp!. Trim luggage Tool Comp!. luggage Compt. Partition Board luggage Comp!. Shelf Board luggage Compllamp Assy. lU~gage Compartment Package omp!. Tool Compl. Deck Step lu~age
rtmenl Open Rear Rack Assy. Open Roof Assy. Top Assy. Roof Panel Assy. Top Slat Iron Top Operating Mechanism Roof Reinf. Retainers • Roof Rail Assembly TOCr~~ ~a~~me lamp-
ts:.lt:
IX
(Continued)
IUSIC PART No·1 BASIC I SERIES SERIES EXPANSION
54900·54999 55000·55199 55200·55999 7060000·7060024 60025·60049 60050·60074 60075·60099 60100·60124 60125·60199
549AOO·549A99 550AOO·551A99 552Aoo·559A99 70600Aoo·70600A24 600A25·600A49 600A50·600A74 600A75·600A99 601AOO·601A24 601A25·601A99
60200·60299 60300·60499 60500·60799
602AOO·602A99 603AOO·604A99 605AOO·607 A99
610oo~1299
60800·60999
608AOO·609A99 61OAOO·612A99
61300·61399 61400·61499
613AOO·613A99 614AOO·614A99
61500·61599 61600·61699 61700·61899 61900·62099 62100·62299 62300·62399 62400·62499 62500·62599
615AOO·615A99 616AOO·616A99 617 AOO·618A99 619AOO·620A99 621AOO·622A99 623AOO·623A99 624AOO·624A99 625AOO·625A99
62600·62799 6280(1..62899
626AOO·627 A99 628AOO·628A99
62900·63199
629AOO·631A99
63100-63199
631AOO·631A99
63200·63299 63300·63399 63400-63499 63500·63599 63600·63699 63700·63799 63800·63899
632AOO·632A99 633AOO·633A99 634AOO·634A99 635AOO·635A99 636AOO·636A99 637AOO·637A99 638AOO·638A99
64000-64099 64200·64399 64400·64599 64600·64699
640AOO·640A99 642AOO·643A99 644AOO·645A99 646AOO·646A99
64700·64799
647AOO·647 A99
64800·64899 64900·64999
648AOO·648A99 649AOO·649A99
65000·65099 65100·65199 65200·65299
650AOO·650A99 65IAOO·651A99 652Aoo·652A99
65300·65399 65400·65499
653AOO·653A99 654Aoo·654A99
65500·65599 65600·65999 &6000·66099 66100·66599 66600·66699
655AOO·655A99 656Aoo·659A99 660Aoo·660A99 661AOO·665A99 666Aoo·666A99
66700·66799
667Aoo·667A99
66800·66899
668Aoo·668A99
66900·66999 67000-61099 671OQ.67199
669Aoo·669A99 670Aoo·670A99 671Aoo·671A99
672OQ.67299 67300-67399 61400-67599
672Aoo·672A99 673AOO·673A99 674Aoo·675A99
PARTS WHICH QUALIFY BY fUNCTIONAL AREA
Roof Ventilator Top Luggage Carrier ODen Fronf seat Assy. Camp!. less Trim Rear Seat Assy.-Opera Seat A$SY. Front Seat Assy. Rear Seat Cushion A$Sy. Driver's Seat Adjustment Rear seat Back Assy.-Deck Seat Back Assy. Driver'S Seat Back Assy. Compo F;Qnt Seat Cushion Frame Assy. Raar Seat Cushion Framing AUX. Seat Cushion Framing Opera Seat Cushion Framing Driver's Seat Cushion Framing Front Seat Back Framing Rear seat Back Frame Rear seat Side Pillar-Front Seat Side Board Rear Seat Side Panel Front Seat Back Panel Front ot Drive Front Driver's Back Reint. Rear Seat Back Rein!. Driver & Passenger Seat Support Rear Seat Legs Front Seat Floor Rest Toe Guard Front Seat Back Robe Cord Front Seat Back Ash Rece&tacle Front Seat Cushion Cover- nter Seat Opera Seat Cushion
Front Seat Cushion SpringCenter Seat Opera Seat Cushion SJ)fing Rear Seat Cushion Spring Seat Cushion Pad Seat Cushion Facin~ Seat Cushion End Pipe Cushion Button Seat Cushion Welt Binding Front Seal Side Carpet Rear Seat Cushion Cover Deck Seat Cushion Cover Driver's Seat Rear Cover Partition Window Operating Mach. Front Seat Back Cushion Cover Seat Back & Pad Assy. Seat Back Division Frame Front Seat Back Spring-Center Seat Frorot Seat Back Pad Front Seat Back Cardboard Opera Seat Cardboard Cover Etc., Center Seat Front Seat Back Facin\ Front Seat Back Trim ail Front Seat Back Cushion Welt & Ml~ Front at Back Wadding Front Seat Back Misc. TrimHassock Assy. Front Seat Back Bellows Open Pedestal Seat Open Rur Seat Back Cover Deck Seat BaCk Cover Rear Seat Back Sprin~ Deck Seat Back Spring Rear Seat Back Pad Deck Seat Back Pad Rear Seat Cardboard Rear Se&1 Back Facing Rear seat Back Cenmr Arm Rest Cover Rear Seat Arm Rest Rear Seat Sijencer Rtar Seat Heelboard
IMPORTANT: AS EACH INDIVIDUAL EXPANSION SERIES 8ECOMES EXHAUSTED Of NUM8ERS, ANOTHER SERIES WILL 8E ESTA8L1SHED 8Y USE Of THE NEXT ALPHA8ETICAL EXPANSION LETTER SUCH AS "8" THRU "Z".
x
GENERAL INFORMATION
FORD TRUC/( PARTS
TYPICAL TRUCK RATING PLATE The Rating Plate is installed on the left front cab pillar or glove box door depending on model. On the Parcel Delivery, it is located on the right hand dash panel.
SERIAL NO. FROM LEFT TO RIGHT TO HAVE THE FOLLOW ING INFORMATION IN THE ORDER LISTED BELOW: - -.....
GROSS VEHICLE WEIGHT
*(ASTERISK) TRUCK SER IAL CODE HORSEPOWER RATING OF ENGINE
ENGINE SYMBOL MODEL YEAR MANUFACTURING PLANT SYMBOL CONSECUTIVE UNIT NO. (BEGINNING 10001) '(ASTERISK)
DOMESTIC SPECIAL ORDER NO.
TRANSMISSION TYPE
P-1533
RAT 10 OF SINGLE OR 2-SPEED AXLE _ _--.-J
The various Rating Plate Codes are shown in detail on the pages indicated below. PAGE NUMBER
COD E
XI XI
Assembly Plant District D.S.O. Engine Exterior Paint Body Color Model Year Production Date Transm issions Truck Series and their Related Catalog Symbols
X
XI XIII
XI X
XI XII
D.S.O. CODE The D. S. O. Code is the Domestic Special Order number assigned to a vehicle using some equipment or parts which were not used in regular production. Always furnish appropriate Rating Plate information when ordering special parts applicable to D. S. O. units.
PRODUCTION DATE CODE CODE
CODE FIRST YEAR A B
C D E F
SECOND YEAR N P Q R S T
MONTH Januarv February March April May June
FIRST YEAR G H J K L M
SECOND YEAR U V
W X
Y Z
MONTH July August September October November December
FOR EXPLANATION OF OTHER RATING PLATE OR WARRANTY PLATE CODES, REFER TO PAGES WHICH FOLLOW. ALSO SEE INDEX ON PAGE II
GENERAL INFORMATION
FORD TRUC/( flARTS
XI
RATING PLATE - CONTINUED 1951-56 TRANSMISSION TYPES & CODES NUMBER OF SPEEDS
T Y P E
1951/52
3 3 3
Standard Heavy Duty Overdrive
4 4
Spur Synchronized
5 5
5Dffi Heavy Duty-Direct Heavy Duty-Overdrive 50D Fordomatic
1953/55
3 3HD
I
3 3HD 30D
ASSEMBL Y PLANT CODES YEAR AND COD~
PLANT
1956
3 3HD 30D
4 4SYN
4SYN
5Dffi 50D Auto
5Dffi 50D Auto
Atlanta Buffalo
AT BF
A B
Chester Chicago
CS CH
C G
Dallas Dearborn
DI
DA
D F
EG HM
Edgewater HIGHLAND PARK
DETROIT TRUCK
MODEL YEAR CODES YEAR
CODE
YEAR
1951 52 1953155 1956
Lorain Long Beach
LB
L
L
Louisville G Memphis
LV MP
V M
V M
D Norfolk Richmond
NR
N R
N
RH SR SP
S P
E
Somerville TWIN CITY (ST. PAUL)
H K
H. Mahwah K San Jose
-
P E R
CODE
5 6
1953 1954
3 4
KC
KANSAS CITY
YEAR AND CODE
PLANT
1,/>1 52 1953 55 1956
--~-
1955 1956
ENGINE CODES ENGINE COD E
NO. CIUNBCIHC CYL. DISP.
NUMBER CARB. VENTUR I
T Y P E
CERTIFIED NET HORSE POWER
R. P. M.
COD E
ENG I N E NU'-1BER NO CUBIC CARB. CYL·.
6~~~.
6 8 8 8 8
223 239 256 279 317
6 6 6 8 8 8 8
D V Z J K
226 215 254 239 337 279 317
6 6 8 8 8
R. P. M.
1956 D V
1953 D M R J K
VENTURI
CERTIFIE NET HORSE POWE R
1954-55
1951-52 H D M R E J K
T Y P E
215 254 239 279 317
D.H.V. ~-head
-head p.H.V. p.H.V.
Z R J A K
6 8 8 8 8 8 8
223 272 272 272 302 302 332
2 Light Duty 2 Heavy Duty 4 Heavy Duty 2 4 2
S
8
332
4
DISTRICT CODES CODE
DISTRICT
Boston ..- - . ----r2 Buffalo 13 New York 11
~
CODE
DISTRICT
CODE
51 52 53
31
Cincinnati ST Cleveland 33 Detroit
DISTRICT
Denver Des Moines Kansas City
CODE
DISTRICT
73 74
San Jose Salt Lake City Seattle
75 81 83
Phoenix Ford of Canada Government Home Office Reserve American Red Cross Diplomatic Service Comm.
72
15 21
PittSburgh Newark Atlanta
35 36
Indlanapolis LanSing Louisville
22 23 24
Charlotte Philadelphia Jacksonville
41 42 43
Chicago Fargo Rockford
62 63 64
Houston Memphis New Orleans
84 85 86
25 26
Richmond Washington
44 45
Twin Cities Davenport
65 71
Oklahoma City Los Angeles
89 Transportation Service 90's Export
14
::14
Omaha ::>t. Louis 1--6"1 Dallas54
55
._-
I
GENERAL INFORMATION
XII
FORD TRUC/( PARTS
RATING PLATE -
CONTINUED
CATALOG MODEL SYMBOLS B
tl
PARTS
CODE REGULARI LI GHT
I
TRUCK SERIES
CATALOG MODEL
HEAVY
TRUCK SERIES
CODE REGULARI LI GHT
SYMBOL
HEAVY
PARTS CATALOG MODEL SYMBOL
I
1951 - 52 F-l F-2 F-3 F-3 F-4 F-5 F-5
F-l F-2 F-3 P-3 F-4 F-5
C-5
Conventional Conventional Conventional Parcel Deliverv Conventional Conventional Cab Over Engine
B-5 B-6 F-6
C
D y J TL
T
C-6 F-7 F-S
F-5 F-6 F-6 F-6 F-7 F-S
School Bus School Bus Conventional Cab Over Engine Conventional Conventional
C-600 F-700 B-700 F-750 B-750 C-750 F-SOO C-SOO F-900
Cab Forward Conventional School Bus conventional School Bus Cab Forward Conventional Cab Forward Conventional
IWH THQ THC!
F-700 B-700 C-700 T-700 F-750 B-750 C-750 F-SOO C-SOO T-SOO F-900 C-900
Conventional School Bus Cab Forward Tandem Axle Conventional School Bus Cab Forward Conventional Cab Forward Tandem Axle Conventional Cab Forward
Z Z ZW Q,Z
QW QH QHW QH QHS QSW
B-700 C-700 T-700 F-750 B-750 C-750 T-750 F-SOO C-SOO T-SOO F-900 C-900
School Bus Cab Forward Tandem Axle Conventional School Bus Cab Forward Tandem Axle Conventional Cab Forward Tandem Axle Conventional Cab Forward
ZW Q,Z Q Q QW JlQH QH QHW QH QHS QSW
W
T
TH TH WH Q
QH
1953 F-l0 F-25 F-35 P-35 F-50 B-50 C-50 P-50 F-60 B-60
F-lOO F-250 F-350 P-350 F-500 B-500 C-500 P-500 F-600 B-600
Conventional Conventional Conventional Parcel Deliverv Conventional School Bus Cab Forward Parcel Deliverv Conventional School Bus
C
C-60 F-70 B-70 F-75 B-75
D y J
T T W JH TH TH
C-75 F-SO C-SO F-90
Q
Q QW QH QHW QHS
1954 - 55 F-l0 F-25 F-35 P-35 F-50 B-50 C-50 P-50 F-60 B-60 C-60 P-60
F-61
C-61 P-61
F-lOO F-250 F-350 P-350 F-500 B-500 C-500 P-500 F-600 B-600 C-600 P-600
Conventional Conventional Conventional Parcel Deliverv Conventional School Bus Cab Forward Parcel Deliverv Conventional School Bus Cab Forward Parcel Delivery
Conventional Conventional Conventional Parcel Deliverv Conventional School Bus Cab Forward Parcel Deliverv Conventional School Bus Cab Forward Parcel Deliverv Conventional
F-70 B-70 C-70 T-70 F-75 B-75
C D
Y J
T T W JH TH TH WH SPECIAL ORDER
F-71
C-71 T-71 F-76
C-75
C-76
F-SO C-SO T-SO F-90 C-90
F-Sl C-Sl T-Sl F-91
C-91
Q Q
1956 F-l0 F-25 F-35 P-35 F-50 B-50 C-50 P-50 F-60 B-60 C-600 P-60
P-61
F-lOO F-250 F-350 P-350 F-500 B-500 C-500 P-500 F-600 B-600 C-600 P-600
F-70
F-71
F-700
F-ll F-26 F-36 P-36 F-51 B-51
C-51 P-51 F-61 B-61
F-63 B-63
C-61
C-63
C D y J
T T W JH TH TH WH SPECIAL ORDER
B Catalog model symbol ts not tncluded on ratwg plate.
Z
B-71
B-70 C-70 T-70 F-75 B-75
T-71 F-76 B-76
C-75
C-76
T-75 F-SO C-SO T-SO F-90 C-90
T-76 F-Sl C-Sl T-Sl F-91
C-71
C-91
T-S4
Z
GENERAL INFORMATION
FORD TRUC#( 'ARTS
RATING PLATE -
CONTINUED
EXTERIOR PAINT BODY COLOR CODES
CODE
I
PART NO.
COLOR
A B D G H
M-1724 M-14285 M-14448 M-14555 M-14197
Black Sheridan Blue Alpine Blue Sea Island Green Silvertone Gray
A
M-1724 M-14285 M-2J-64
II
CODE
1951 M N P SS
PART NO.
COLOR
M-14283 M-1722
Meadow Green Vermilion Prime Special
M-14~l:l~
Meadow Green Vermilion Prime Special
1952 K
M-2J-16
Black Sheridan Blue Woodsmoke Gray Glen Mist Green Sandpiper Tan
A B
M-1724 M-14285 M-2J-184 M-2J-64 M-2J-187
Black Sheridan Blue Glacier Blue Woodsmoke Gray Seafoam Green
M-1724 M-14285 M-2J-184 M-2J-258 M-2J-175
Black Sheridan Blue Glacier Blue Sea Haze Green Vermilion
M-1724 M-2J-346 M-2J-347 M-2J-355 M-2J-354 M-2J-349
Black Banner Blue Aquatone Blue Waterfall Blue Snowshoe White Sea Sprite Green
M-1724 M-2J-521 M-2J-523 M-2J-524 M-2J-527 M-2J-175
Black Nocturne Blue Diamond Blue Colonial White Meadow Mist Green Torch Red
B D G
M-~J-titi
M N P SS
M-l'(~~
1953 C
D G
N R
M-1722 M-14283
Vermilion Meadow Green Prime Special
M-14283 M-2J-358
Meadow Green Goldenrod Yellow Prime Special
M-2J,-175 M-14283 M-2J-358
Torch Red Meadow Green Goldenrod Yellow Prime Special
M-14283 M-2J-531 M-2J-532
Meadow Green Golden Glow Yellow Platinum Gray Prime Special
P SS
1954 A B D H R
U
V P SS
1955 A B C
D E
G
R U
V P SS
1956 A B D E
G R
U
M H P S
XIII
GENERAL INFORMATION
XIV
FDRD TRUC/( 'ARTS PAINTS, THINNERS, ETC.
CONTAINER SIZE
YEAR
DESCRIPTION
OO··I.OZ II&OZ·I ..·T )QUA.T!.AL-l..AL·IOO.AL
PART NUMBER
THINNERS and REDUCERS
x x x x
x x x x x x x
B7A 645-8 M14J 645-D M14J 645-E M14J 646-E M14J 646-H DL60647-A M14J 647-D M14J 647-E M14J 647-H M14J 648-D M14J 648-E
Leveler (spray can) Lacquer thinner No.1 (slow dry) Lacquer thinner No.1 (slow dry) Lacquer thinner No.2 (medium fast dry) Lacquer thinner No.2 (medium fast dry) Enamel reducer Lacquer thinner (all purpose) Lacquer thinner (all purpose) Lacquer thinner (all purpose) Enamel reducer (all purpose) Enamel reducer (all purpose) UNDERCOATS
M 6J 12-D M 6J 12-8 M 6J 13-D
Lacquer comb. primer surfacer - Gray Lacquer primer surfacer - Gray (spray can) Lacquer comb. primer surfacer - Red
x x
x
RUBBING COMPOUNDS
M
Rubbing compound-hand (water base)
3789
PUTTIES and SEALERS
C3AZ 19B542-A C3AZ 19560-A
Dark Gray putty lacquer, 1 lb. tube Body sealer SPECIAL TIES
Argent-lacquer Argent (spray can) Torch red-synthetic enamel Torch red (touch up paint-with bruSh)_ Torch red (spray can) Dewaxo (wax & grease remover) Bonding coat (transfer film) Water soluble transfer solution Meadow Green (spray can) Meadow Green-synthetic enamel
x x x x
x x x
x
x x
M 2J M 2J M IJ M 4J M2J M M M M M
23-L 23-8 175-C 175-A 175-8 3721 4584 5412-A 14283-8 14283-8E
M M M IJ M IJ M 4J M 4J M 4J B8A
165-A 1292-8 1724-C 1724-D 1724-C 1724-D 1724-8 3713-A
BLACK and WHITE FINISHES
Ford black (brushing) White (refrigerator) - spray can Black-synthetic enamel Black-synthetic enamel Black-lacauer Black- lacquer Black - lacquer (spray can) Chassis black
x x
x x
x x x
x
YEAR
I
DESCRIPTION
CODE
I
I
PART NUMBER
II
YEAR
I
DESCRIPTION
ICODE I
I
PART NUMBER
LACQUERS and SYNTHETIC ENAMELS TOUCH UP PAINT - 30%. CAN - WITH BRUSH
56 55 56/
Nocturne Blue Snowshoe White Colonial White
B E E
M 2J 521 M 2J 354 M 4J 524-A
56 56 56 1
Meadowmist Green Platinum Gray Goldenglow Yellow
G H M
M 2J 527 M 2J 532 M 2J 531
LACQUER PAINT - PINT CAN
.;::5ci5-,-+S~n~ow~s'i-h:.:;oe,;..Wh~i=:-te=--_ _+-~+-___---1c.,;:M:;....:;2;..;.J~35;.4;..-.;L~
56
Colonial White
M 2J 527-L
Meadowmist Green
M 4J 524-B
SYNTHETIC ENAMEL PAINT - QUART CAN
55 56 56/
I Banner Blue
I Diamond Blue I Colonial White
B D E
1M 2J 346-8E 1M 2J 523-8E 1M 1J 524-C
I
56 55/
Meadowmist Green I G Goldenrod Yellow (1955-V)(1958-9-X)
TOUCH UP PAINT - 60%. SPRAY CAN
56/
Colonial White
E
1M 4J 524-8
II
1
M 2J 527-SE M 4J 358-C
FORD rRueR 'ARrs
GENERAL INFORMATION
xv
APPEARANCE & MAINTENANCE MATERIALS DESCRIPTION
PART NUMBER rROTUNDASALESNQ)
Clear plastic(FoMoCo spray) -6 oz.aerosol can 16 oz. can with brush B7A 19000-BS Chrome-alum.(FoMoCQ spray}-Q oz .aerosol can CIAZ I9000-A Waint (GlOSS Green-MX 6041168j-Enamelair dry -1 gal. can Paint (Gloss Green-MX tiU'llltits)-.!';namelCIAZ 19000-B air dry-5 gal. can !paint (Gloss Green-MX 6041168)-EnamelCIAZ 19000-C 55 gal. drum COAA I9A50I-A .::;01 vent &, penetraung UUla - manllold heat control valve-3 oz. can with plastic spout eUA£. IIJA:JUI-A ::SOlvent & penetratIng llUlU-~ oz. can B7A 19000-AS
(R 149-A)
C4AZ, IIJA:JUI-A
(RUO-A)
B9AE 19B508-A (RIl2-A)
8A
system)-l~
oz. can
19510-A
(RI23-A)
B9A
Iprotector (chrome) -12 oz. Aerosol ::;pray can
(RI24-A)
o AB
19515-A
ItlOdy underCOatIng-oJ gal. arum(water emULSIOn)
(RIOB-B)
B5A l\Jolo-A
ItlOdy underCOating-03 gallon arum -regular
(RlOB-A)
IA
1\Jo17
IDusting cloth-wax treated-17 1/2' x 23"
(RIl6-A)
tsA
IIJol'{
B'lA
Custom auto polish-4-1 gal. plastic bottle
IIJ5J'l-A
custom auto wax-ts oz. can
(RI2B-B)
B8A 19534-A
Custom auto wax I-lb. can
(RI2B·A)
B7A 19542-B (RI03-B) (RI03-C) (RI03-A)
CJAZ, llitl:J'l2-A
Brake & hydraulic clutch fluid (heavy duty)1 gallon Brake & hydraulic clutch fluid (heavy duty)5 gallons Brake & hydraulic clutch fluid (heavy duty)12 oz. can Putty (darK gray)-l lb. tube
(R 14B-A)
C2RZ 19C543-A
Tire inflator and sealant kit
(R140-A)
B7A 19544-A
Anti-freeze (Methanolj-55 gal. drum
(RIOO-A)
lA
19544-A
Anti-freeze(Methanol)-1 gal. can
(RlOO-B)
19544-C
Anti-freeze (Methanol) -1 quart can
(RIOO-C)
C3RZ I9C544-A
De-icer (windshield spray)-14 oz. aerosol can
(RI42-A)
HA
lli:J4o-C
(RI04-A)
• CIAA I9B546-A TAAA19547-A C3HZ, IliC:J4'{-tl C2RZ 19C548-A
19519-A
Cleaner (body polish & waxl-l pint can
(RI22-A)
B7A 19520-A
Tar & road oil remover-16 oz. can
(RI26-A)
8A
19530-D
ttaCUator rust Innlbtor & water pump lubricant-16 oz. Lubricant(Hypoia additive)-4 oz.plastic bottle Fire extinguIsher fluid-l quart LUDTlCant (Std. , ;S & 'I speea trans. )- 0 gal.
IHymplecloth-polishing-2H" x 28"
(RIl6·B)
8A
custom ::;illcone GlOSS (NeW car prep)-I gal.
(RlII-D)
lA B9A 19514-A
Silicone auto polish-16 oz. can
(RlIl·C)
B7AZ 19542-A
vleaner (Convertible rear windOwj-8 oz. plastic bottle Contact adhesive! gasket & seal) 16 oz. can with brush Dye( c onve riIble top are ssmg) -1 qt. can (B lackj
CIAZ 19C507-A
B7A 19530-B
Solution (metal tinning}-6 oz.aerosol spray can Cleaner (COollng
DESCRIPTION
(RlIl-A)
B7A I9542-C
(RI02-A)
C2Rz, 19A:JOJ-A
B7A I9530-A
::;01vent&penetranng Iluid-12 oz. can
(Rl49-B)
CIAZ I9C502-A
PART NUMBER
(ROTUNDA SALES NO.)
(R l41-A)
C2AZ 19549-C (RIOO-F)
19520-G
Cleaner (body porcelainizej-l gal. can
C'IAZ, llio'lli-A
Spot Remover (chlorothene cleaner)-l pint can
C4AZ, llJ;)4lJ-ti
Power steering & automatic transmission additive-8 oz. can Anti-Freeze (permanent type-long life)55 gal. drum Antl-!reeze (all season coolant)-l gal. can
(RIOO-G)
B7A 19521-A (RI2I-A)
COAA 19B52I-A Icompouna (ooay washlngaetergent)-I2 oz. can (R 127-A)
8A
I9549-A
8A
1\J54IJ-B
(RIOO-D)
COAZ 19522-A 8A 19522
I
Cleaner( chrome) -12 oz .plastic bottle w;brush Cleaner (Chrome)-1 pint can
(RI20-A)
(RIOO-E)
CPA I9550-A
B8A 19523-A
cleaner (Whitewall tire) -1 qt.nqulQ concentrate
(R1l9-B)
B8A
Anti-freeze (all season coolantj-l qt. can
(RIOO-II)
(RI09-B)
C1AA 19550-A
19523-B
Cleane r ! all purpose) -1 gal. plastic bottle
Anti-freeze-nermanent tvne-I gallon(Ethylene Glycol) Anti-freeze-permanent type-l quart(Ethylene Glycol) Windshield washer solvent-6 oz. bottle Windshield washer solvent-16 oz. can
(RI09-A)
(R119-A)
B8A 19524-A
Sprayer Self Energlzlllg-1 quart
(R6I-A)
19552-B
Rubber cement-5 oz. tube
(RI33-A)
C3RZ 19524-A {R6I-B}
B5A 19525-A C2AZ 19C525-A
l:,pray applicator (1 pint containerj-for use with B8A 19523-B all purpose cleaner Kar Klean (all purpose trimcleaner)~80z.can
(Rl1B-A)
COAZ 19526-B (R IlB-B)
B7A 19528-A 8A 1 IJ52IJ-tl B6A 19530-A
COAZ 19552-A COAZ 19553-A
Trlm cement (VInyl adheSIVe)-l plllt can Interlor trIm Cleaner-lor leathers, VlllYls,carpets & fabriC upholstries-12 oz .bottle w/brush Deep cleaner-upholstery foam cleaner-32 oz. plastic bottle Porcelalffize nqUla-ti oz. ootues POrCelalffiZe (WaSh cream)-8 oz. batue vustom body POliSh-12 oz. plaStiC bottles
(RIll-B) Available to New York City Dealers only
Rubber cement-5 oz. tube (light colored) Silicone lUbricant (jell typej-ts oz. tube
(RIl3.A)
COAZ 19553-C
(R114-A)
COAZ 19526-A
V
8A
Silicone lubricant-16 oz. aerosol spray can
(RIl3-C)
C3AZ 19554-A C3AZ 19554-B B5A 19554-A (RI34-B)
COAA 19554-A (R I04-B)
tsA
111:J:J'I-tl
(RI34-A)
Sealant-(loctite)-1 2/3 oz. plastic bottle ::;ealer (cOnductive)-3 oz. can with brush Perfect seal sealing compound-carton of 12 4 oz. cans HadiatOr illh1DitOr-rust, Stop leaK &, water pump lubricant-5 1/2 oz. bottle Perfect seal sealing compound-I pint
GENERAL INFORMATION
XVI
FORD TRUC/( PARTS
APPEARANCE & MAINTENANCE MATERIALS - continued PART NUMBER
DESCRIPTION
lROTUNDA SALES NO.}
protector pellet (cooling system}-carton of12 pellets Protector pellet \coOling system) -1 carton containing 300 pellets individually wrapped Caulking cord-6-80 foot rolls- 3/16" diameter
B6A HI558-A (RI05-A)
COAZ 19558-A (RI05·B)
AB
PART HUMBER
19560-A
C2A:t. 19580-A
Hypoid gear lubricant (rear axle) -110 lb. keg (S.A.E.90) Hypoid gear lubricant (rear axle}-5 gal. container-So A. E 80 (temperature rangeminus 25 0 and below) Lubricant (differential gears & washer)-1 lb. can-apply to differential case side, gear hub bores before assembly I ::speedometer cable grease-1 lb. can
C2AZ 19580-B C~AZ
(RI35-A)
1958u-E
jjo